Product ID:EPOXY HARDENER, 72-PG
MSDS Date:03/14/1995
FSC:8010
NIIN:00N067100
Kit Part:Y
MSDS Number: CBFLB

CARDINAL INDUSTRIAL FINISHES

1329 POTRERO AVE
SOUTH EL MONTE, CA 91733
US

Emergency Phone: 800-424-9300(CHEMTREC)

Info Phone: 818-444-9274

Preparer: RICHARD STEWART

Cage: 65860

CARDINAL INDUSTRIAL FINISHES

SOUTH EL MONTE, CA 91733 US

Telephone: 818-444-9274 OR 213-283-9335

Cage: 65860

22 @ 20C.

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 8%

OSHA PEL 200 PPM

ACGIH TLV: 50 PPM, S

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

2-BUTANONE; (METHYL ETHYL KETONE) (MEK) (SARA 313)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 2.76%

OSHA PEL 200 PPM

ACGIH TLV: 200 PPM;300 STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

PHENOL, 2,4,6-TRIS(DIMETHYLAMINOMETHYL)-;

CAS: 90-72-2

RTECS: SN3500000

Fraction By Weight: 1.96%

OSHA PEL 5 PPM (MFR)

ACGIH TLV: 5 PPM (MFR)

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES:CAN CAUSE IRRIT & REDNESS,
TEARING/BLURRED VISION. SKIN:MOD IRRIT POSS FROM PRLNG EXPOS, DEFAT
& DERM. INHAL:NASAL IRRIT, HDCH, DIZZ, NAUS, WEAK/VOMIT, LOSS OF
CONSCIOUSNESS. INGEST:GI IRRIT, HDC H, DIZZ, NAUS, WEAK. WARNING,
DETECTABLE AMTS OF CHEM KNOWN TO STATE OF CALIFORNIA TO CAUSE
CANCER &/OR(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:BIRTH DEFECTS/OTHER REPRO HARM MAY BE
PRESENT IN THIS PROD (CALIFORNIA HLTH & SFTY CODE 25249.10).
NOTE:TOLUENE APPEARS ON NAVY LIST OF OCCUP CHEM REPRO HAZS. SEEK
CONSULTATION FROM APPROP HL TH PROFESSIONALS CONCERNING LATEST HAZ
LIST INFO & SAFE HDNLG & EXPOS INFO . PAINT & SOLVS HAVE BEEN (SUPP
DATA)
Medical Cond Aggravated by Exposure:PRE-EXISTING RESPIRATORY
CONDITIONS, PRE-EXISTING SKIN DISORDERS, LIVER & KIDNEY DISORDERS.

First Aid:EYES:FLUSH W/WATER FOR AT LEAST 15 MINUTES. GET MEDICAL
ATTENTION IMMEDIATELY. SKIN:WASH EXPOSED AREAS W/SOAP & WATER.
REMOVE CONTAMINATED CLOTHING. INHAL:REMOVE TO FRESH AIR. IF
BREATHING IS DIFFICUL T, ADMINISTER OXYGEN. IF BREATHING HAS
STOPPED, GIVE ARTIFICIAL RESPIRATION. GET MEDICAL ATTENTION.
INGEST:DO NOT INDUCE VOMITING, KEEP PERSON WARM & QUIET. GET
MEDICAL ATTENTION.

Flash Point Method:TCC
Flash Point:24.0F,-4.4C
Lower Limits:1.3%
Upper Limits:11%
Extinguishing Media:FOAM, DRY CHEMICAL, CARBON DIOXIDE, WATER FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:FLAMMABLE LIQUID - CLASS 1B. CONTAINERS
MAY DEFORM OR EXPLODE WHEN EXPOSED TO EXTREME HEAT. DECOMPOSITION
PRODUCTS MAY YIELD OXIDES OF CARBON & NITROGEN.

Spill Release Procedures:REFER TO FIRE & EXPLOSION RISK, HEALTH HAZARD
DATA, REACTIVITY DATA, SPILL/LEAK PROCEDURES & SAFE HANDLING & USE
INFO SECTIONS. ELIMINATE ALL IGNITION SOURCES. ABSORB LIQUID IN
ABSORBANT MATERIAL & PR EVENT SPREADING TO GROUND WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:FOR INDUSTRIAL USE ONLY. USE ONLY
W/ADEQUATE VENTILATION. FOLLOW PRECAUTIONS OF THIS MSDS TO PREVENT
OVEREXPOSURE.
Other Precautions:CONTAINERS OF THIS MATERIAL MAY BE HAZARDOUS WHEN
EMPTIED. SINCE EMPTIED CONTAINERS RETAIN PRODUCT RESIDUAL (VAPOR,
LIQUID &/OR SOLID), ALL HAZARD PRECAUTIONS IN THIS MSDS MUST BE
OBSERVED.

Respiratory Protection:IF TLV OF PROD/ANY COMPONENT IS EXCEEDED, A
NIOSH/MSHA APPRVD AIR SUPPLIED RESP IS ADVISED IN ABSENCE OF
ENVIRON CONTROL. OSHA REGS ALSO PERMIT OTHER NIOSH/MSHA APPRVD
RESPS UNDER SPECIFIED CNDTNS (SE E YOUR SFTY EQUIP SUPPLIER). (SUPP
DATA)
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL &/OR LOCAL EXHAUST)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Protective Gloves:CHEMICALLY RESISTANT GLOVES SUCH(SUPDAT)
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS .
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . PVNT RPTD/PRLNG SKIN CONT BY USING GB
(SUPDAT)
Work Hygienic Practices:WASH HANDS BEFORE EATING OR USING REST ROOM,
SMOKE IN SMOKING AREAS ONLY.
Supplemental Safety and Health
EFTS OF OVEREXP:LINKED TO LIVER ABNORMS, KIDNEY & LUNG DMG. RESP
PROT:ENGINEERING/ADMIN CONTROLS SHOULD BE IMPLEMENTED TO REDUCE
EXPOS. PROT GLOVES:AS:POLYVINYL ALCOHOL COATED/POLYETHYLENE. OTHER
PROT EQUIP:PROT HAND CREAM. WEAR IMPERVIOUSCLOTHING & CHEMICAL
RESISTANT BOOTS.

Boiling Pt:B.P. Text:>175F,>79C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:0.98
VOC Pounds/Gallon:110
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:12.9

Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:EXTREME TEMPERATURES.
Hazardous Decomposition Products:DECOMPOSITION PRODUCTS MAY YIELD
OXIDES OF CARBON & NITROGEN.

Waste Disposal Methods:DESTROY BY LIQUID INCINERATION I/A/W APPLICABLE
REGULATIONS. CONTAMINATED ABSORBANT SHOULD BE INCINERATED OR SENT
TO AN APRPOVED LANDFILL I/A/W LOCAL, STATE & FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.